Clutch replacement ("Ford-Focus 2)": practical advice, cost

Date:

2020-01-16 23:20:14

Views:

495

Rating:

1Like 0Dislike

Share:

Table of contents:

The Basic units in any car – is the engine and box. They are closely interrelated. However, at the time of the shift the two nodes disconnect. Therefore, in the design of any car with a manual transmission provides a friction grip.

clutch replacement Ford focus 2

This mechanism transfers and the smoothing of the efforts of torque that goes to the box. Replacement clutch – a highly complicated operation. However, it is quite possible to do yourself. Today we tell, how is the car “the Ford-Focus-2" clutch replacement with your own hands.

Site Features

“Magic” is set to single plate friction clutch with a diaphragm spring. The site is operated by the hydraulic actuator. The clutch mechanism consists of several elements:

  • Release bearing.
  • Drive.
  • Plug.
  • The worker and the main cylinder of coupling.
  • Shopping Basket.

replacement clutch slave cylinder for Ford focus 2

The Latter is located between the engine flywheel and the leading disk. Basket includes two friction plates connected by rivets. Also in the construction of a diaphragm spring. It provides a snug fit of the spring has damping properties, i.e., smooths the efforts of torque. Due to this, the car picks up speed smoothly and without jerks.

About the online

When the car needs a clutch replacement? “the Ford-Focus-2” can nurse on one disc up to 150 thousand kilometers. But it all depends on driving style. If the driver prefers aggressive management with frequent wheelspin, a resource of this clutch will be less than 60 thousand km. Another point – the load of the vehicle. If you are driving with a trailer, be prepared for more frequent replacement of the clutch. By the way, in case of breakage of changing the whole basket Assembly.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

Cause

With time on the slave drive have cracks. Weakened rivets, burrs appear on the friction plate. Another reason – damage to the gaskets and seals. As a result, the oil from the box gets to the basket. The clutch starts to slip even with minimal loads.

replace clutch master cylinder Ford focus 2

Fork almost no wear, but the replacement clutch master cylinder (“the Ford-Focus-2” is no exception) may be required after 100 thousand kilometers. The reason – the fault contours. The system pressure may fall, causing cutoffs for disk have to do more.

How do I define failure?

Since the difference between the intervals is high enough, you need to be able to identify the fault at the hearing. So, the main signs of failure of the clutch are:

  • A lot of wheelspin at the start (without kickdown).
  • Incomplete activation or deactivation of the transmission.
  • The Appearance of excess vibration.
  • Jerks when shifting gears.
  • Thud when releasing clutch pedal.

Ford focus 2 clutch replacement with your own hands

If operation fails release bearing. Determine the fault is quite simple. From the engine compartment you will hear a rumble in neutral. When squeezing the pedal it disappears.

Repair cost

It is Worth noting that when faults occur, it is required to change all elements in the collection. The only way to ensure a long and trouble-free operation after repair. The cost of a new clutch kit for gasoline cars “the Ford-Focus-2” is 6 thousand rubles. For diesel – thousand rubles more expensive. The most expensive to maintain are robotic transmission DSG. The cost of the clutch kit is 12 thousand rubles. To set the node to the robotised box is possible only in a specialized service. How much is a clutch replacement? “the Ford-Focus-2” with DSG you can serve for 8 thousand roubles. Single baskets can be replaced independently.

Preparation

For the successful replacement of the node we need the following tools:

  • Set of flat spanners and sockets.
  • A Jack or pit.
  • Capacity to drain the oil from the transaxle.

In Addition, we will need new disc and trash the clutch and release bearing.

Start work

So, what does replacing the clutch? “the Ford-Focus-2” is placed on a viewing hole or just a flat surface. Next you need to open the hood and remove the battery. For convenience, the shelf also extract the battery and the air filter housing. After this key remove the tube hydraulic clutch.

how much to replace clutch Ford focus 2

Now pour the oil from the gearbox into a prepared container. Next, Unscrew the bottom engine mount. Then dismantle the ball joint and get the drive wheels. In the next step, Unscrew the fastening of the transmission and pull her out. Now go to the clutch. It is attached to the six bolts. Next, take out the basket with the driven disk. With a screwdriver hold the flywheel from turning.

Installation

Now you can put newrelease bearing, disc and clutch basket. Important point – with the installation of the basket should be centered strictly on the pins of the flywheel. Otherwise, the node will not function correctly.
For convenience it is recommended to install the transaxle input shaft (buy it separately) and have it install the node. Shaft remove and install the transmission itself. This replacement clutch (“the Ford-Focus-2”) successfully completed. You can start full operation.

Replacement clutch slave cylinder

“the Ford-Focus-2” may require replacement and this item. First remove battery and air filter. Next, pump out the old fluid with a syringe to the lowest level. Remove the tube that is supplied to the clutch cylinder. From the clamp pull the hose (with a screwdriver use it to pry out the locking clip). replace clutch master cylinder Ford focus 2Disconnecting the tube, disassemble the clutch pedal. It is removed with the bracket. It remains only to disengage from the pedal cylinder and swap it. At the end of the work required to remove air from the system. To do this, Unscrew the special valve and repeatedly tap the pedal until it comes out clean the liquid.

Conclusion

So we figured out how to independently replaced clutch. “the Ford-Focus-2” – the car is rather simple in terms of technical devices. Therefore, replacement of clutch (if it's not automated manual) problems should arise.


Article in other languages:

AR: https://tostpost.com/ar/cars/20708-clutch-replacement-ford-focus-2-practical-advice-cost.html

BE: https://tostpost.com/be/a-tamab-l/38319-zamena-schaplennya-ford-fokus-2-praktychnyya-rekamendacy-kosht.html

DE: https://tostpost.com/de/autos/37908-austausch-der-kupplung-ford-focus-2-praktische-tipps-kosten.html

ES: https://tostpost.com/es/coches/37682-la-sustituci-n-del-embrague-ford-focus-2-consejos-pr-cticos-el-precio-.html

HI: https://tostpost.com/hi/cars/22349-clutch-replacement-ford-focus-2-practical-advice-cost.html

JA: https://tostpost.com/ja/cars/20327-clutch-replacement-ford-focus-2-practical-advice-cost.html

KK: https://tostpost.com/kk/avtomobil-der/38720-auystyru-kerek-ford-fokus-2-t-zh-ribel-k-synymdar-ny.html

PL: https://tostpost.com/pl/samochody/40304-wymiana-sprz-g-a-ford-focus-2-praktyczne-wskaz-wki-cena.html

PT: https://tostpost.com/pt/carros/39945-substitui-o-da-embreagem-ford-focus-2-pr-ticas-o-valor-de.html

TR: https://tostpost.com/tr/arabalar/35181-debriyaj-de-i-imi-ford-focus-2-pratik-neriler-maliyeti.html

UK: https://tostpost.com/uk/avtomob-l/39113-zam-na-zcheplennya-ford-fokus-2-praktichn-rekomendac-vart-st.html

ZH: https://tostpost.com/zh/cars/26250-clutch-replacement-ford-focus-2-practical-advice-cost.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

VAZ-2104: tuning with your hands

VAZ-2104: tuning with your hands

2104 Car, tuning which really perform on their own, are in great demand in the domestic market. With proper care and proper maintenance, the machine is reliable and will last a long time and in a regular vehicle. However, many own...

"Ford Focus 2": replacement of the hub with your hands

“the Ford-Focus-2” – very popular in Russia car. His popularity he gained thanks to the high reliability, maintainability and budget price. Among car owners are of the opinion that to fix the car is much more com...

Car alarm Starline D94: installation and owner reviews

Car alarm Starline D94: installation and owner reviews

Signaling system D94 was a continuation of a series of telematic systems security company Starline. And if the previous versions of the A-family of the calculation was the cars, then the line D is focused on off-road segment. In t...

Tuning UAZ-452:

Tuning UAZ-452: "Loaf" in a new guise

UAZ-452 – well known to all utility special vehicle. It is different all-wheel drive, high cross and the wheel formula 4x4. Because of the similarity with a loaf of bread popularly called "Loaf". Good model, only t...

Truck GAZ-33086

Truck GAZ-33086

the GAZ-33086 – a truck which is produced at the Gorky automobile plant since 2005. According to its characteristics, "Countryman" (simplified name of the truck) takes an intermediate position between the truck GAZ-3309 and ...