Thermostat "Opel Astra H": description, features, replacement, and device

Date:

2020-01-16 06:00:15

Views:

580

Rating:

1Like 0Dislike

Share:

Table of contents:

The cooling System of an internal combustion engine requires periodic servicing. Often it comes down to replacing the antifreeze every 1-2 years of operation. Unfortunately, this is the wrong approach, because this system is quite complex and has a large number of parts, each of which performs its role during operation of the motor. Let's look at the thermostat "Opel Astra H" and device.thermostat Opel Astra h

Device and principle of operation

The thermostat Consists of a spring, a cylinder and a special pin. The essence of the work lies in the fact that in a closed cylinder contains a wax in the form of a ball. Under the influence of temperature it begins to melt and expand. The pressure pushed the pin which in turn opens and closes the valve.

It Turns out that initially, a large circle is closed and coolant only circulates in a small circle. When reaching a certain temperature (operation) valve opens and the cooling liquid circulates on the big circle through a radiator. Work in a small circle provides more rapid heating of the motor, and a large Bo - effective cooling while riding. This is, in fact, the radiator and the fans. The radiator in modern cars is cooled either by air flow or is blown by fans.

How to understand what the thermostat is "Opel Astra H" defective

This node fails rarely, but it happens. If you do not notice the damage in time, it is possible to overheat the motor or waiting hours for a warm-up to operating temperature. All this is due to the jamming of the thermostat valve.thermostat Opel Astra h price

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

To Stay, he can as in the closed position and in the open. If the thermostat is stuck with the valve closed, then upon reaching a certain temperature circulation on a large circle is not the cooling efficiency of the motor is reduced. As a result, overheating. If the valve is open, the car will be a long time to warm up and increase fuel consumption. In any case, you need to understand that jokes with the cooling of the engine is bad and the sooner taken, the better.

Removing thermostat on "Opel"

The Process of dismantling this site on the car brand "Opel" is somewhat different from the others. The first thing you need to understand where is located the thermostat. It is located to the right of the engine, between the battery and motor closer to the latter. For work on the replacement thermostat you need to remove the battery and preferably the area of its fastening. It is very simple, drop the terminal and turns the three bolts.

The Next step - remove the terminal from the thermostat housing and remove the nozzle. Will result in a certain amount of antifreeze, so prepare in advance Tara. After that, Unscrew 4 torx-screws (asterisk) and take out the thermostat. At the same time you can do a visual examination. If the rubber valve seal has failed, then replacement. The same applies to the case of jamming. In principle, the replacement of the thermostat to "Opel Astra H", is the same as any other car brand, except that in our case you need to remove the battery for a more comfortable experience. Now go ahead.thermostat Opel Astra h 1.6

Thermostat "Opel Astra H" Z18XER: customer testimonials

One of Sanych is buying a new thermostat. Today a huge number of them. The best of them - original. However, these products have a high cost, but the quality is almost always consistent. There are Chinese counterparts, they are characterized by low cost and poor quality. To put such thermostats is not recommended because of their unpredictability.

The best option - quality analogue. It can be any of the characteristics of the thermostat from another vehicle or from a famous brand at an affordable price. Consumer reviews mostly boil down to buying the original. Its price is about 800–1000 rubles, but the quality is at very high level.thermostat Opel Astra h z16xer

Related work

As noted at the beginning of this article, the cooling system should be regularly maintained. If you decide to change the thermostat, it's time to pour new antifreeze and put the filler cap. The latter also has a valve that is triggered when a certain pressure in the system. If he does not hold, then the antifreeze will not boil at 120-125 degrees and at 105. If he is stuck in the closed position, it may break the radiator due to overpressure.

In any case, it is better to install the new cover and replace the antifreeze, especially if it had not been done. As for the coolant, then there is also important to pay attention to its quality. It is desirable, of course, cover what is recommended by the manufacturer or certified counterparts. Poor quality coolant can lead to such unpleasant consequences as the constant tripping of the cooling fan, boiling, etc.

Health Check thermostat

Often the replacement of a unit is not required, and the problem may be caused by other reasons. In this case, it is recommended to check the thermostat. To make it simple enough. On warm engine it is necessary to try the top and bottom pipes comingto the radiator. Both should be hot. If the lower is cold, this indicates a stuck valve in the closed position. Consequently, the coolant does not circulate in a large circle.replacement thermostat for Opel Astra h

You Can also try the bottom of the radiator if it is cold, and the bottom pipe is hot, then it is likely clogged. In this case, before replacing the antifreeze a few times to flush the system and clean the radiator outside, as it becomes clogged with road dirt. If the thermostat is "Opel Astra H" 1.6 is still inoperative, then it must as soon as possible to replace.

What are the findings

As you can see, to replace the thermostat "Opel Astra H" Z16XER is not difficult. This can be done with a minimal amount of tools. All work will take from one hour to two. But you can gain experience and a few thousand savings. Try to monitor the integrity of the system. If there is a leak in the radiator, then it needs to be eliminated. To do this, or sapav or replacing with new. You can also use a special powder, which is hot filled into the filler neck of the cooling system with the engine running. The powder can tighten a small leak and thus solve the problem for a while.thermostat Opel Astra h z16xer reviews

As you can see, there is nothing difficult to change a thermostat "Opel Astra H". Its price is about a thousand rubles (the original), a quality equivalent to cost 600-700 rubles, and Frank China - 300-400. Not such a big amount to save, the more that is done is quite responsible and has to work like clockwork. It is crucial to buy a suitable thermostat, as there are "late" and "early". The difference between them is that one is displayed with a slight delay, and others before. Better use the VIN number the car and buy just what stood out from the factory.


Article in other languages:

AR: https://tostpost.com/ar/cars/20694-thermostat-opel-astra-h-description-features-replacement-and-device.html

BE: https://tostpost.com/be/a-tamab-l/38309-termastat-opel-astra-n-ap-sanne-asabl-vasc-zamena-prylada.html

DE: https://tostpost.com/de/autos/37898-thermostat-opel-astra-h-beschreibung-merkmale-austauschen-und-das-ger-.html

ES: https://tostpost.com/es/coches/37672-termostato-opel-astra-h-descripci-n-caracter-sticas-sustituci-n-y-el-d.html

HI: https://tostpost.com/hi/cars/22337-thermostat-opel-astra-h-description-features-replacement-and-device.html

JA: https://tostpost.com/ja/cars/20317-thermostat-opel-astra-h-description-features-replacement-and-device.html

KK: https://tostpost.com/kk/avtomobil-der/38710-termostat-opel-astra-n-sipattamasy-erekshel-kter-auystyru-zh-ne-ornatu.html

PL: https://tostpost.com/pl/samochody/40294-termostat-opel-astra-h-opis-cechy-wymiana-i-urz-dzenia.html

PT: https://tostpost.com/pt/carros/39935-termostato-opel-astra-h-descri-o-caracter-sticas-substitui-o-e-disposi.html

TR: https://tostpost.com/tr/arabalar/35171-termostat-opel-astra-h-tan-m-zellikleri-yedek-ve-cihaz.html

UK: https://tostpost.com/uk/avtomob-l/39103-termostat-opel-astra-n-opis-osoblivost-zam-na-pristr-y.html

ZH: https://tostpost.com/zh/cars/20534-opel-astra-h.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

How to drain the antifreeze from the VAZ-2110: instruction

How to drain the antifreeze from the VAZ-2110: instruction

Antifreeze & ndash; and the cooling liquid (coolant) used in automotive internal combustion engines. Due to resistance to low temperatures, excellent heat exchange properties and low cost, it enjoys a great popularity among ca...

Excursion into history: motorcycle crawler

Excursion into history: motorcycle crawler

Recently, motohito there was a topic to discuss innovations in the field of design of two-wheeled vehicles. The conceptual model presented techniques developed by a group of Chinese students. They presented motorcycle crawler, whi...

Trucks

Trucks "Ural": features

Trucks «Ural» is an all - terrain vehicle with all-wheel drive. Produced at the Ural automotive plant. There are various technology options. Some of them are discussed later in the article.«Ural» (truck): c...

What is diesel? The working principle, structure and technical characteristics of the diesel engine

What is diesel? The working principle, structure and technical characteristics of the diesel engine

Diesel engines are quite common on cars. Many models have at least one option in the engine range. And this is excluding trucks, buses and construction equipment where they are used everywhere. Further considered that such diesel,...

A filter separator for diesel fuel: design

A filter separator for diesel fuel: design

In the diesel fuel, which is sold at gas stations of our country, contains a lot of heavy and harmful engine contaminants. Also in the DT is bound to have the wax particles and water. If the car will be a long ride on such a fuel,...