Wipers VAZ-2110: replace with your own hands

Date:

2020-01-11 05:00:11

Views:

523

Rating:

1Like 0Dislike

Share:

Table of contents:

Anyone who has ever driven a car with broken windshield wipers in heavy rain or snow, can tell how hard it is and dangerous. Not to get into a similar situation, you need to monitor the condition of the wiper blades and in a timely manner to change them.

Wipers VAZ 2110

In this article we'll talk about what constitutes wipers VAZ-2110. We will also review the design of the wiper mechanism and will deal with the most common problems.

How does the wiper “dozens”

The Mechanism of a windshield wiper of the car VAZ-2110 consists of the following elements:

  • Motor;
  • A-line (power-driven);
  • The control module (switch modes);
  • Elements of electrical protection;
  • Leashes janitors;
  • Brush.

Motor

The windshield Wipers of a VAZ-2110 car driven by an electric motor. Its design includes gearbox and three current-carrying brushes, thanks to which it can work in three speed modes. Motor wipers VAZ-2110 is located in a special compartment under the grille from below the windshield.a-Line wipers VAZ 2110

Mechanical drive

The Drive of the wiper blades is a system of levers and rods movably connected to each other in the form of a trapezoid. It is located in the engine compartment below the windshield and is designed to convert rotational motion of the motor shaft into reciprocating and Vice versa. Thus, a-line wipers VAZ-2110 causes the brushes to move synchronously and in the same plane.

Module control

The Management mechanism of the wiper is carried by a separate switch located on the steering column to the right. It has four modes:

  • Inactive (wipers VAZ-2110 is located in the state of rest);
  • Intermittent (the brushes move with the certain interval);
  • Quick;
  • Very fast.

Security features

Since the drive electric wipers, its the circuit protected by the fuse. It is mainly the mounting block and is designated the F-5. If you do not operate the wipers on VAZ-2110, the Troubleshooting should always begin with him.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

do Not operate wipers VAZ 2110

The frequency of the strokes of the brushes in the discontinuous mode is governed by a separate relay. It is also mostly the mounting block and is denoted as K-2. In case of violation of the periodicity of operation of the wipers “dozens” it must be replaced. To attempt to diagnose or repair the relay is impractical because it costs a little more than 200 rubles.

Leads

Leashes janitors VAZ-2110 – machine elements that transmit force from the crank of the trapezoid directly to the brushes. In other words, it's Reiki, which, in fact, move the wipers on the windshield. The trapezoid they are fastened with slots and locking nuts. At the ends of leashes janitors “dozens” there is a special attachment in the form of a hook.

Brush

Regular brush VAZ-2110 made up of three elements:

  • Frame;
  • The brush
  • Fixtures.

The Frame is made of metal and has a composite construction that includes a main rail and an additional two located on it. Brush is made of soft rubber. In the middle of its working surface there are longitudinal projection (keel), which actually cleans the glass. The brush is attached to two additional rails of the frame, entering into their grooves. To the janitor to glide easily on the glass, some manufacturers cover the working part of the graphite.

Ticker janitors VAZ 2110

In the center of the main slats includes a fixing mechanism by which it attaches to the leash. It is a guide which engages the hook of the leash and the plastic latch that secures the connection.

Frameless wipers

In the sale is a frameless wiper blade. The main feature of their design is the lack of a metal frame. It is the role of the plastic pressure plate. These brushes differ in the smoothness, lack of squeaks caused by loose connections, corrosion. In addition, they do not “whistle” when driving at high speed.

When should you replace the windshield wipers

The Resource is “desyatnyk” brushes is 500 thousand cycles. If we translate these numbers into the area that they could clean, it will be 50 football fields. But, whatever it was, change the wipers, it is recommended once a year. And do it preferably before the onset of cold weather. Of course, the wipers VAZ-2110 can lose its efficiency before. The reason for this may be, for example, damage due to freezing to the windscreen or deformation caused by constant exposure to the sun. In such cases, the brush also needs to change.

Replacement wipers VAZ 2110

Dimensions

Regular wipers “dozens” have a standard length of 51 cm, and it is the same for the brush that is located on the driver side and the one that is on the passenger side. But to uphold this standard is optional. On VAZ-2110, you can set the wipers to the following lengths(driver's side/passenger sm):

  • 50/50;
  • 51/48;
  • 53/50;
  • 53/51;
  • 53/53;
  • 55/45;
  • 60/50;
  • 63/48.

Follow some tips when choosing the length of the brushes is not necessary. If only they after you install does not overlap the review and not clung to a protective grid.

What kind of brushes to choose

Determine the size of the wipers, do not rush to buy the first model. The fact that the auto parts market today is crowded with fakes. Pokopavshis on some $ 100, you can purchase wipers that effectively will last a few days, and then begin to creak and leak water. It is better to give preference to well-known manufacturers, and purchasing to implement in a specialty store. With regard to the design, then you have to decide buy “beskarkasnymi” or regular. Importantly, the bindings match.

Replacement wipers VAZ-2110

The Process of replacing wipers on “ten”, as, indeed, on any other car, is very simple and won't take more than five minutes. And tool any not necessary. The procedure works the following:

  • Windscreen cover with a thick cloth to protect it from possible damage;
  • Turn down the leash wiper from the windshield;
  • Raise the latch of the fastening mechanism up, turn the frame 90 degrees around the guide and sliding it down, removing the hook of the leash;
  • Guide a new janitor sets up a hook fastening and driving it to the end of the bend until the latch clicks.

How to care for your windshield wipers to extend their life

To janitors served as long as possible, follow these tips:

  • Stained with dirt brush, wipe clean with a damp cloth or sponge. So you not only get rid of dirt, but also will protect the glass from scratches.
  • If the front glass was covered with a layer of dust, and the washer of the car is over liquid, do not operate the cleaner. It will also lead to the formation on glass scratches.

Leashes janitors VAZ 2110

  • In the winter, especially in snow, do not leave the wipers, leaning against the windshield – they'll freeze you. It is better to hold the leashes so that the brushes were in limbo.
  • If the wipers still frozen, in any case, do not try to pull them off by force. So you can damage the gum. Start the engine, turn on the stove in the mode of blowing the windscreen and wait until it defrosts.
  • To break the ice with the frame or the brush is also impossible. Gently bend the rubber as long as he does not loose small parts.
  • By replacing the wipers, put on the windshield of some dense fabric. It will save it in case the spring loaded leash will slip out of your hands.


Article in other languages:

AR: https://tostpost.com/ar/cars/20616-vaz-2110.html

BE: https://tostpost.com/be/a-tamab-l/38253-dvorn-k-vaz-2110-zamena-sva-m-rukam.html

DE: https://tostpost.com/de/autos/37845-scheibenwischer-vaz-2110-der-austausch-mit-ihren-h-nden.html

ES: https://tostpost.com/es/coches/37627-los-porteros-vaz-2110-la-sustituci-n-de-sus-manos.html

HI: https://tostpost.com/hi/cars/22276-wipers--2110.html

JA: https://tostpost.com/ja/cars/20259-vaz-2110.html

KK: https://tostpost.com/kk/avtomobil-der/38660-aula-sypyrushylar-vaz-2110-auystyru-z-olymen.html

PL: https://tostpost.com/pl/samochody/40228-wycieraczki-vaz-2110-wymiana-w-asnymi-r-kami.html

PT: https://tostpost.com/pt/carros/39862-limpadores-de-p-ra-brisa-vaz-2110-substitui-o-de-suas-m-os.html

TR: https://tostpost.com/tr/arabalar/35110-silecekler-vaz-2110-yedek-elleriyle.html

UK: https://tostpost.com/uk/avtomob-l/39042-dv-rniki-vaz-2110-zam-na-svo-mi-rukami.html

ZH: https://tostpost.com/zh/cars/20970-vaz-2110.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

"Moskvich 434": specifications, photos

Each of us saw a car like "Muscovite". Now these machines are becoming a thing of history. "Moskvich 434" is no exception. To find a really “live” the copy is not possible. Often, many people associate these ...

"Lada Largus Cross": owner reviews, all cons, photos

In 2014, the Russian concern "AVTOVAZ" has presented the unusual novelty. We are talking about the “off road" modifications of the passenger wagon, which became known as the «Lada Largus Cross”. Reviews by r...

Throttle

Throttle "Lancer-9": the possible damage, repairs, replacement

the Car ‘Mitsubishi Lancer” – survivor the Japanese car industry (now available for the tenth generation). It is appreciated for its ruggedness, reliability, good maintainability. Motorists also attract a good mi...

How to check catalyst oppression: a step by step instruction device and recommendations

How to check catalyst oppression: a step by step instruction device and recommendations

every year in the world of stricter environmental standards. At the moment in the European Union used cars with the exhaust is not below the “Euro 4». In Russia less demanding environmental exhaust. However, even moder...

Caterpillar on the motorcycle with your hands

Caterpillar on the motorcycle with your hands

Some motorcycles are better suited to convert a ATV (snowmobile)? In the winter snowy period for many motivedecay comes the idea to create from your motorcycle ATV. It is necessary to set the caterpillar on wheels. To make this po...