The restoration of the reflector of the headlight with your hands: instruction, description and reviews

Date:

2019-12-18 19:20:16

Views:

557

Rating:

1Like 0Dislike

Share:

Table of contents:

Any items in modern cars is subject to wear, and sometimes these elements can fail even before your online. This fate exposed and car lights. They are especially delicate part is the reflector. If the level of damage is low, but the detail is only slightly faded or burned out, then it is possible to recover the reflector with your hands. It will not cause any special difficulties.

Why rebuild?

When the reflectors are dull, this causes deterioration of automotive optics. Do not try to ignore this situation. Because of the high quality illumination of the roadway depends on the visibility and the safety of the driver of the car. restoration of headlight reflectorAlso to find reflectors that will fit under the replacement impossible. And new headlights – it is too expensive. So the best option – home recovery reflector headlights.

Types of reflectors

Car lights have a fairly simple design. So, this product consists of a lamp and reflector. The first one can not adequately cover part of the road. To do this, and use the reflectors, which help to create a luminous flux of rays. For high efficiency operation of this item must be in good condition.

Design and capabilities of a particular model optics distinguish the following types detalii:

  • Parabolicheskie.
  • Bifocals.
  • Novokuzne.
  • Polyellipsoid.

The causes of the destruction of reflectors headlight

Over time, the condition of the coating of the reflector can be destroyed, then you will need to restore the reflector headlights. restoration of the reflector with your handsIntegrity and reflectivity of the coating can be violated due to several reasons. This can often be related to physical effects of leakage, the ingress of moisture. In addition, the quality of the operation of the optics may be affected by temperature changes.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

Experts do not recommend using incandescent lamps with different power ratings. This can significantly disrupt the optics. If the requirements are not followed, surface is just burned out, and then you must repair the mirror coating of the reflector of the headlamp.

Of Course, it is much easier to replace the item, however to find the suitable spare part can only be in the automotive critiques. Recovery – is the best solution to this issue. Using this process can achieve greater efficiency of the reflector and its resource.

Among the most simple, effective and popular solutions you can apply the following steps:

  • Re-coating the reflector with metalized duct tape.
  • The Use of foil and epoxy glue.
  • The Use of mirrored film “ORACAL 325” or “ORACAL 351”.
  • Using chrome paint.

Method # 1

Before you begin the recovery process, you must remove and disassemble the headlight completely. Then the design must be heated to allow the sealer has lost all of its properties and characteristics. Then all of the elements of the headlamp can be separated from each other. Reviews say, to warm up the optics, it is better to use ordinary oven. And if you have a building dryer can be used it. In the case of the oven it will be enough 30 minutes at a temperature equal to 75 degrees.

Next starts the recovery of the reflector of the headlights. restore cover to the reflectorAll work will be carried out using metallized tape. Only this material has all the necessary features and is glued to the surface of the reflector.

First, measure and then cut the required pieces. To cut the need for the form that best fits to the reflector. Then, the surface of the reflector must be degreased, and then you can start gluing the individual elements. Further, the corrugated part is better to cover the chrome.

Method # 2

The restoration of the headlamp reflector by this method will be made using metal foil and epoxy glue. restoring a mirrored coating reflectorSo, as a result the product will have high strength and service life are also greatly increased. It is worth saying that this method has one significant disadvantage-the glue dries very slowly.

Initially performed all demolition and preparatory work. Then made a pattern out of paper. Then cut off the pieces of foil and glued on the product. That's all.

Method # 3

In this method of recovery uses a mirror film. Motorists say the high efficiency and effectiveness of the method. For this method to approach any film. But the best way to cope with this task the product from “Oracle” №351 and 352.

This mirror film is made of polyester. This material also has all the necessary properties and has good reflectivity. Besides, these films are not susceptible to deformation and wear. In order to restore the reflector of the headlamp at home, to disassemble, to dismantle, clean and grease the working surface of the reflector.

Then with duct tape dopattern. On the basis of the layout rascherchivanija and cut film. Strips glued with construction Hairdryer. After sticking the tape must be smooth. This can help building a Hairdryer. Corrugated parts can be painted with chrome spray.

Recovery reflector headlights with paint

The Reviews say that this procedure will be effective only if the reflector is a little faded or dimmed. If the reflector was cracked, the surface is oxidized or swollen, then using paint to solve the problem will fail. paint restoration headlight reflectorsThe first step is to thoroughly clean the inner surface of the reflector. Reviews say that for effect, you can use the microfiber cloth and white spirit or kerosene. It is important to remember that it is unacceptable to use any other types of solvents or alcohol. This can have a negative impact on the characteristics of the reflector.

So next, you need to heat the mirror up to 40-50 degrees. This is done with the dryer, or the reflector is heated in a thermal Cabinet. Next, you should spray across the surface layer of Motip Clear Vanish. This is a special varnish. It is very important that the process of deposition took place in a single call.

Next, you need to sustain the reflector about 2-3 minutes on air. recover reflector priceThus it is necessary to constantly monitor the situation, to avoid water stains. Then the reflector is covered with a layer of varnish, again placed in the closet for a few hours. It is necessary that the paint for the restoration of the reflectors of the headlights has dried thoroughly. This will take no more than 5 hours. At the last stage, the spotlight is going. Reviews motorists recommend to the Assembly to apply the new sealant as the old one no longer has the necessary properties.

Professional headlight restoration

If none of the above methods did not help, then you should turn to professionals. Today, many stations are ready to offer motorists the service. In the professional restoration of the reflectors do not use tape or paint. This applies to the restoration of the reflector by vacuum deposition. This process requires specific equipment. So it is very difficult to conduct in the garage. Even if you can restore the mirror finish at home so it is inefficient.

The Reviews tell that chromium deposited by electroplating, inefficient as it is decorative. Stanovlenie to the reflector by vacuum depositionEspecially when you consider that the restoration to the reflector price is not small (5 thousand rubles), it's much more effective to apply one of the described ways.

In General, to restore the reflectors do not need serious investment and effort. The most important thing – to buy quality materials and fully follow the instructions. And then all must succeed.


Article in other languages:

AR: https://tostpost.com/ar/cars/20306-the-restoration-of-the-reflector-of-the-headlight-with-your-hands-inst.html

BE: https://tostpost.com/be/a-tamab-l/37971-adna-lenne-adb-val-n-ka-far-sva-m-rukam-nstrukcyya-ap-sanne-vodguk.html

DE: https://tostpost.com/de/autos/37604-wiederherstellung-der-reflektor-der-scheinwerfer-mit-seinen-h-nden-anl.html

ES: https://tostpost.com/es/coches/37366-la-recuperaci-n-del-reflector-del-faro-con-sus-propias-manos-la-instru.html

HI: https://tostpost.com/hi/cars/22011-the-restoration-of-the-reflector-of-the-headlight-with-your-hands-inst.html

JA: https://tostpost.com/ja/cars/19965-the-restoration-of-the-reflector-of-the-headlight-with-your-hands-inst.html

KK: https://tostpost.com/kk/avtomobil-der/38377-alpyna-kelt-ru-sha-yldyr-ysh-shamdardy-z-olymen-n-s-au-sipattamasy-zh-.html

PL: https://tostpost.com/pl/samochody/39908-regeneracja-reflektora-wiate-w-asnymi-r-kami-instrukcja-opis-i-opinie.html

PT: https://tostpost.com/pt/carros/39555-a-recupera-o-do-refletor-do-farol-com-suas-pr-prias-m-os-a-instru-o-a-.html

TR: https://tostpost.com/tr/arabalar/34849-kurtarma-reflekt-r-far-elleriyle-deyim-tan-m-ve-g-r-ler.html

UK: https://tostpost.com/uk/avtomob-l/38779-v-dnovlennya-v-dbivacha-far-svo-mi-rukami-nstrukc-ya-opis-ta-v-dguki.html

ZH: https://tostpost.com/zh/cars/36546-the-restoration-of-the-reflector-of-the-headlight-with-your-hands-inst.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

Tolls for trucks over 12 tons: the new rules, reviews

Tolls for trucks over 12 tons: the new rules, reviews

in the autumn of last year Russia introduced tolls for trucks over 12 tons. 1, 2015 the cost of travel on Federal highways is 3.7 rubles per kilometer. While municipal and regional authorities will independently determine the valu...

A hernia on the wheel - can I drive? Hernia repair on the wheel

A hernia on the wheel - can I drive? Hernia repair on the wheel

Many car owners don't too neat ride on the roads. The roads are not always good. Sometimes this drive can lead to various deformations of the cord in a car tire. After that, the sidewall will act as so-called hernia. Many wonder w...

What is the best car? Customer reviews

What is the best car? Customer reviews

Everyone wants to have in its garage was a good car. But many in the head triggered the stereotype regarding what truly good cars are expensive. However, this view is mistaken. There are budget machines that will serve its owner f...

The refrigerator is a Refrigerator... on a

The refrigerator is a Refrigerator... on a "Gazelle" (photo)

the Delivery of goods is given special attention, especially when it comes to food and perishable products. In this case you need to save as much as possible not only presentable, but also to ensure that the goods have not lost th...

Charger for car battery

Charger for car battery

Every car enthusiast at least once in life faced with the problem of complete discharge of the battery in which use was not possible. And this applies to all vehicles, whether imported or domestic.Sometimes this kind of fault is q...