Not working retractor starter relay. What to do?

Date:

2020-02-19 19:20:09

Views:

438

Rating:

1Like 0Dislike

Share:

Table of contents:

Many motorists have observed a picture when the engine of their car was not run for them for some strange reason. We are talking about the problems with the starter when turning the key we do not hear and do not feel the operation of the device, but only strange clicks coming from under the hood of the car. Do not be afraid, as these sounds come from the retractor starter relay, which is in faulty condition (if the starter clicks, but no spinning, then the fault is not there). In principle, this is a common failure not only domestic cars but also cars from around the world. Unfortunately, to correct this situation is possible only with a significant improvement of the design of the starter.

So, before you learn how to repair in this situation, you need to understand that the retractor starter relay? In fact, it is the electromagnet, which give it a constant current is driven in accordance with the laws of electromagnetic induction. We need this in order to the one-way starter clutch, popularly referred to as a Bendix, was a member in secure engagement with the engine flywheel and rotates it to start the engine. Of course, if in the chain will be any problems, and the engine will not start, at least with the starter. On the other hand, the overrunning clutch cannot be in permanent connection with the flywheel, since that is physically impossible.

Now a few words about what is a starter? From the point of view of electrodynamics – this is the most common electric motor, but the peculiarity of it is that it at relatively low speed uses a fairly high current of approximately 350 A. this is Achieved by using two windings on the stator and rotor with a special selection of number of turns and the cross sectional area of the wire. But such a large current is needed in order that through the flywheel could rotate the crankshaft of the engine and run it. That's why the starter can't work for a long time, and he needs to rest.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

Now for the fault. It should be remembered that not working is not the starter and pull the starter relay, so it is necessary to repair it. This requires the first stage to check the battery charge, as the weak charge can also lead to clicks. Next, you need to check the weight of the body and engine as well as loose battery terminals. If all these points leave no doubt, some of the visual checks you can still see mounting the starter to the motor as sometimes the bolts on it are weakened, leading to unstable weight.

If now the fault is not installed, then you need to remove the device and disconnect the retractor starter relay. In cases where this relay can be assembled and disassembled back several times, it is necessary to disassemble it and inspect the contents for signs of deformation and burning. If the security bolts (“penny”) burnt, they can be cleaned and back together. Basically, the reason for the clicking relays, this is because force bolts are constantly in contact and their burnt – this is a natural process. Can also limit power cable that goes from one of the windings on the retractor starter relay.

In this case, you need the power cable thoroughly clean, to poledit solder in the place of burning and, if possible, to solder it. This operation is best done in repair shops, although in the home this operation is quite feasible. If solder fails, or if a substantial breach of the insulation winding of the power cable, you will have to disassemble the entire starter (but this failure is very rare).

Now you know some of the subtleties and nuances with the malfunction of the starter motor and the retractor relay. If desired, and in the presence of basic tool, this problem you can always fix. But to prevent this from happening, try not to turn on the starter for a long time, especially in winter!


Article in other languages:

AR: https://tostpost.com/ar/cars/21176-not-working-retractor-starter-relay-what-to-do.html

BE: https://tostpost.com/be/a-tamab-l/38750-ne-pracue-cyagvacca-rele-startara-shto-rab-c.html

DE: https://tostpost.com/de/autos/38281-funktioniert-nicht-retraktor-relais-des-anlassers-was-kann-ich-tun.html

ES: https://tostpost.com/es/coches/38058-no-funciona-retractor-rel-del-motor-de-arranque-qu-debo-hacer.html

HI: https://tostpost.com/hi/cars/22778-retractor.html

JA: https://tostpost.com/ja/cars/20798-not-working-retractor-starter-relay-what-to-do.html

KK: https://tostpost.com/kk/avtomobil-der/39124-zh-mys-starter-n-tartu-reles-ne-steu-kerek.html

PL: https://tostpost.com/pl/samochody/40747-nie-dzia-a-zwijacz-przeka-nik-rozrusznika-co-robi.html

PT: https://tostpost.com/pt/carros/40417-n-o-funciona-vtyagivayuschee-rel-de-partida-o-que-fazer.html

TR: https://tostpost.com/tr/arabalar/35603-al-m-yor-retrakt-r-r-le-mar-ne-yapmal-y-m.html

UK: https://tostpost.com/uk/avtomob-l/39534-ne-pracyu-vtyaguyuche-rele-startera-scho-robiti.html

ZH: https://tostpost.com/zh/cars/37432-not-working-retractor-starter-relay-what-to-do.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

"Volkswagen Tiguan": owner reviews on all the cons of the car

the Germans have always been quality and safety of their cars. What do you think? The German auto industry deserves respect and special attention. Most brands began their existence in Germany. Now it is customary to say that a car...

The ventilation in the garage: what to choose?

The ventilation in the garage: what to choose?

Some car owners believe that good ventilation in the garage - it is not of first importance. This is a profound misconception. Because of the ventilation system depends not only on the condition of the vehicle, but also the health...

Volkswagen Polo Sedan reviews

Volkswagen Polo Sedan reviews

a Car Volkswagen Polo Sedan, which reviews evidence of a fundamental new style, embodies an elegant and sleek design. The execution of each line of the case with clarity, simplicity and elegance allows to argue about the sophistic...

Chery Tiggo. Reviews

Chery Tiggo. Reviews

Russia's Automotive market today is no shortage of samples available machines. The products of the domestic automobile industry can compete with foreign cars. Pretty fertile ground for the development of their brands in the vastne...

How to perform a heated steering wheel

How to perform a heated steering wheel

heated steering wheel is an additional option that allows the driver to drive in the winter in the cold. On many cars of premium and business class, the system already goes to completion. How to be car owners who are deprived of t...