Flipper - a protective strip between the disc and wheel

Date:

2020-02-09 09:20:09

Views:

469

Rating:

1Like 0Dislike

Share:

Table of contents:

To protect your camera uses a special tape called "flipper" imposed on the inner surface of the wheel rim.

The purpose of the flipper

Tires and set the inner chamber is made of rubber and special rubber compounds. Despite the fact that the composition of resinosis depending on destination car tyres, scope, period of operation use special chemical additives to increase the stiffness, the car wheel is still soft enough, vulnerable material.

flipper's

In the operation of any car is a gradual wear of the tires, which is accompanied by increased friction with the temperature increase and the occurrence of mechanical wear particles. Flipper is a special tape that performs as a protective strip between the camera and the rim of the wheel. It protects the camera from damage that could cause arose in the process of exploitation of the products of wear from the outside or trapped debris.

Manufacturer

The flipper is an integral part of the wheel that does not have its parameters degrade the specs, wheels and performance characteristics of the car. Currently flap is installed primarily on truck tyres since its application in the passenger car tyre reduces dynamic performance that is especially noticeable on high speed models.

flipper wheel

Despite the fact that the jointing tape is used in truck tires, it's the flipper creates difficult conditions. Given this factor, for the manufacture of V-belts used are not the most expensive grades of rubber compound. Often includes a large percentage of rubber, discarded on technological violations in the manufacture of tires and reclaimed rubber, recycled car tires.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

Marking

To ensure reliable, long-lasting, and safe operation of a vehicle wheel, it is imperative that all components: tire, camera, flap, rim - meet certain interrelated parameters. To determine such conformity, with the purpose of proper selection and staffing, and introduced a system of notation and classification, including for rim tape. For flipper this notation indicates the following properties:

  1. The Name of the manufacturer.
  2. Seat sizes (in inches), consisting of specifying the nominal width of the tape and rim size wheel rim.
  3. Production Date.
  4. Stamped on the passport control for correct operation.

seal between the disk and the camera

Storing and installation of the flipper wheel

For safety and to prevent loss of performance properties, avoiding premature aging, the rim tape should be stored in compliance with binding requirements.

  1. Not allowed-simultaneous storage of flippers with lubricants and flammable materials, solvents, other aggressive substances.
  2. The storage location of the flipper wheel should be located in a dry building or room, be sure to closed against the sunlight.
  3. Do Not allow the contact of the strips of material subject to corrosion or low corrosion resistance.
  4. Placement of flippers storage should be carried out on semicircular surfaces of special brackets or rails in bundles not more than 20 pieces.
  5. Storage Temperature can range from +30 to -30 °C.

To install the gasket between the disk and the camera is required in accordance with the current technology for the Assembly-disassembly of car wheels, with mandatory compliance with approved safety regulations. Flipper is an integral part of the wheel which does not require separate measures for care and maintenance.

flipper camera

Causes of loss of efficiency of the flipper

The Main reason for the failure of the flipper is a gap between air pressure in the tire normative parameters. At low pressure the wear, and thus drastically shortens the life of the wheel. At high pressure, and when you Overdrive the car, in the valve hole of the rim is squeezing the rim tape first and then the rubber of the camera. The result of such an accident is loss of the integrity chamber and the pressure loss. This leads to the escapement wheel, it is almost always loaded on a vehicle leads to destruction of the tires. Also usually non-restore the camera and flipper.

To avoid such defects, there is the design of the rim tape, which was first used by Michelin. This flipper provides for the installation of a special plastic insert under the valve hole. The purpose of this insert is to prevent the penetration of the rim tape and camera into the slot on the rim. This solution extends the life of the car wheel, but only in cases of short-term exposure to high internal pressure or overload of a motor vehicle.


Article in other languages:

AR: https://tostpost.com/ar/cars/21036-flipper---a-protective-strip-between-the-disc-and-wheel.html

BE: https://tostpost.com/be/a-tamab-l/38581-flipper---geta-aho-naya-prakladka-pam-zh-dyskam-kameray-koly.html

DE: https://tostpost.com/de/autos/38163-flipper-ist-eine-sch-tzende-dichtung-zwischen-der-scheibe-und-der-kame.html

ES: https://tostpost.com/es/coches/37942-flipper-es-un-protector-de-la-junta-entre-el-disco-y-la-c-mara-de-la-r.html

HI: https://tostpost.com/hi/cars/22646-flipper---a-protective-strip-between-the-disc-and-wheel.html

JA: https://tostpost.com/ja/cars/20634-flipper---a-protective-strip-between-the-disc-and-wheel.html

KK: https://tostpost.com/kk/avtomobil-der/38989-flipper---b-l-or-anysh-t-seu-arasynda-y-disk-zh-ne-do-ala-kamerasymen.html

PL: https://tostpost.com/pl/samochody/40605-flipper---to-ochronna-uszczelka-mi-dzy-dyskiem-i-kamer-ko-a.html

PT: https://tostpost.com/pt/carros/40276-flipper-um-protetor-de-junta-entre-o-disco-e-a-c-mera-de-rodas.html

TR: https://tostpost.com/tr/arabalar/35467-flipper---bu-koruyucu-conta-aras-nda-disk-ve-kamera-tekerlekler.html

UK: https://tostpost.com/uk/avtomob-l/39398-fl-pper---ce-zahisna-prokladka-m-zh-diskom-kameroyu-kolesa.html

ZH: https://tostpost.com/zh/cars/33270-flipper---a-protective-strip-between-the-disc-and-wheel.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

The auto Obrucheva, 23, page 1: reviews, how to get

The auto Obrucheva, 23, page 1: reviews, how to get

currently, plenty of dealers. All of them have different quality of service. How do you determine where it is better? For this it is best to read reviews from real people. In this article, we present the motor show at Obrucheva, 2...

How to test glow plug in a diesel engine without removing?

How to test glow plug in a diesel engine without removing?

Many motorists are interested in the question of how to test glow plug in a diesel engine, as in cold weather fails to start the car. And here there are nuances. The fact that multiple faulty spark the diesel engine can still be r...

An all-terrain vehicle GAZ-3409

An all-terrain vehicle GAZ-3409 "Bobr": description, features and reviews

Many regions of Russia are not equipped with roads available for travel on conventional wheeled vehicles. The situation is often not correct and various off-road machines. For delivery of people and goods in such places created a ...

Protective film on the numbers of cameras: reviews

Protective film on the numbers of cameras: reviews

Can I use to protect from the media images of the traffic police special film? Today, most of the roads mounted police radars that determine velocity. Notice the camera during movement almost impossible. To not receive notificatio...

Michelin Latitude Sport 3: the owner reviews, photos, review

Michelin Latitude Sport 3: the owner reviews, photos, review

Despite the fact that there are a huge number of manufacturers of car tires, most drivers prefer the most famous brands. Popular rubber of the French company "Michelin". When choosing the tyres for premium SUV should pay attention...