VAZ 2114, generator: overview, fault, tips alignment

Date:

2018-04-30 19:00:40

Views:

907

Rating:

1Like 0Dislike

Share:

Table of contents:

On the car VAZ 2114 generator – three-phase electric machine producing alternating current. Inside it there is a block with rectifiers, which allows you to convert the current (three-phase) to DC. To repairs, you need to know the generator device and the main damage that can happen. So we have to consider everything in order.

Design of generator sets

VAZ 2114 generator

  • Cover made from aluminum alloys. They are special sockets that zapressovyvajutsja bearings. On the back cover is a terminal connecting to the battery and connector (“dad”) for connection to the excitation winding. Also on the back cover fixed capacitor. With it suppressed interference. Brush Assembly mounted in one housing with a voltage regulator VAZ 2114. The generator works due to the fact that the stator winding is induced EMF created by a rotating magnetic field of the rotor.
  • Stator recruited from plates made from special grades of transformer steel. It has special grooves, which are placed in the power winding. Each has an output to connect to the rectifier. The stator bolts are fastened cover. The excitation winding is on the rotor. The connection it made to the rings of copper. They are on the shaft. Set the front pulley on the rotor under it there is a keyway.
  • Mount the diode unit made to the back cover inside. It consists of nine semiconductors – six major and three additional. To ensure quality cooling of semiconductors using plates of aluminum alloy. And on the front part next to the pulley is the impeller.

Specifications

generator on VAZ 2114 price

Brief description of the technical characteristics of the generator:

  • Power rotor winding (excitation) voltage the value of which is in the range of 13.2-Volts to 14.7.
  • Under load of 10 kg belt slack (on a long stretch) is not greater than 0.8 cm
  • The Generator VAZ 2114 (the price of it in shops around 4 000 - 4 500 rubles) can give the network current up to 80 A.

Is the unit on the left side, the drive is provided by the V-ribbed belt from the pulley on the crankshaft of a car engine.

Recommended

"IZH 350 Planeta Sport" – frisky Soviet bike

It is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the line went down the fir...

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

Breakdown in mechanics and electricity

spare parts for generators

Does such a failure to increase the level of noise of generator set. The reason – the destruction of one of the bearings. As a rule, that which is in the front cover – it is exposed to very heavy loads especially when a belt of the generator VAZ 2114 is too tight. For this reason you should always monitor the tension of the drive belt of the generator.

As for damage to electrical parts, they can occur in the absence of the charging voltage of the battery or its low (sometimes too high) value. To check the serviceability is not necessary to remove the generator from the vehicle. To do this, use a multimeter. Spend measurements of the voltage at the terminals of VAZ 2114. Generator when working should produce about 14 Volts. If it is 12 Volts and below, the generator produces the desired voltage and needs to be repaired. In some cases the fault lies with the voltage regulator or worn brushes.

Tools for removing generator

To the engine block is attached to the bracket (around the middle). The body is connected the generator to the bracket on the block with a special strap. Thanks to her you receive the ability to adjust the belt tension. To remove the generator, you'll need this tool:

  • Wrenches (preferably a captive and carob) with dimensions “10”, “13”, “17”, “19”.
  • On some vehicles you may need to face head on “15”.
  • A Small pry bar or short length of pipe.

The dismantling of the generator from the vehicle

belt of the generator VAZ 2114

If you need to replace the bearing of the generator VAZ 2114, will require the unit to be totally removed. First need to disconnect the battery. Without this it is impossible to begin repair – short circuit can lead to the ignition wiring. Then, using the key on “17”, weaken the tension of the drive belt. To do this, Unscrew the nut at the top and pulls the body to the engine block. A little work with electricity – twisting the nut with bolt (pin “31”) and disconnect the wire going to the field winding.

The Bottom fastening of the generator is produced by using long bolts and nuts. The last is a plastic thread lock. The top strap is fastened to the stator of one nut and the engine block with two bolts. All of the threaded connection unscrews to remove the generator. If threads are stuck, use penetrating lubricant – it will get rid of dirt and rust. Removed the generator up – so it is easier. But you can remove the protection of the engine and pull it down on the car VAZ 2114 the generator can be removed in two ways.

Disassembly of the generator

replacing the generator VAZ 2114

Tool:

  • The Key to “10” and “19”.
  • Screwdriver.

Before you start make sure all parts for generators purchased. The procedure of disassembly of the generator:

  • Press the latch and remove the plastic casing from the body.
  • Mark the position of the caps and stator relative to each other – this will facilitate later Assembly.
  • Using a Phillips screwdriver, remove the two bolts that secure the voltage regulator with brush Assembly.
  • Disable the slider.
  • Remove the screws that block the rectifier diodes. Detach the insights of the stator windings and remove the node. Please note that with him is dismantled and the condenser. With the help of the voltage of the generator VAZ 2114 “cleaned” from the variable component.
  • Unscrew the four screws, then remove the back cover.
  • Clamp in the vise and Unscrew the rotor nut from the pulley.
  • Remove the front cover.
  • Visually assess the condition of the units. If anywhere has a strong wear, will have to carry out repairs.

How to determine the fault?

Signs of breakdowns in the generator:

  • On the dashboard is illuminated (momentary or constant) light, indicating that no charging-red battery.
  • There is insufficient or excessive charge of the battery.
  • Lights Shine dimly or much of their blinking, and the wipers are in an unstable, constantly changing the speed.
  • Boil the electrolyte in a battery, the headlights Shine bright, sometimes burning lamps.
  • There are noises from the generator.

This is a short description of the problem, but you need to consider them in more detail, to repair the generator VAZ 2114. The price of a full repair will be no more than 1 200 rubles.

Failure of the brush mechanism

brush generator VAZ 2114

To Split the display into two types: failure of the brushes or voltage regulator. Replace the brushes, and relay control is performed without removing the generator. Diagnosis can be done also means at hand – a couple of AA batteries, a battery, a bulb or tester. The cost of the brush unit is quite low, so you can not test it, and immediately put a new one and forget about problems. But if you liked the idea, that diagnosis is as follows:

  • Connect the power to the voltage regulator.
  • Incandescent Lamp connected to the brushes.
  • At a voltage of 12-14 Volts the bulb glows.
  • When you increase to 15-16 Volts it goes off.

This is normal operation of the regulator. If the diagnostics lamp behaves differently, we can talk about the failure of the relay-regulator. It is also worth to mention the wear on the brushes:

  • On-Board network, a decrease in voltage.
  • Charging the battery is not supplied.
  • Observed surges.

After removing the brushes visually assess their condition – if length is less than a half centimeter, they may be disposed of safely. Also note how the moving brush generator VAZ 2114 in the grooves-if there is binding, then it is better to install a new one or drop a little pure oil. Be sure to evaluate the condition of the slip rings on the rotor, sometimes they need to be sanded. After you install the new brushes take a few minutes to start to work properly.

Diode rectifier

the voltage of the generator VAZ 2114

Two signs of failure of the diode bridge:

  • No charging at the battery.
  • Charging much higher than normal.

This damage can lead to rather negative consequences. If you doubt your abilities, it is best to entrust the repair of a generator to a person who specializiruetsya on it. This files most often fail two diodes but replacing them is problematic, as separately these parts for generators not for sale. Much easier would be to buy a new one and install it. The replacement is done in the following sequence:

  • In the block, the Assembly pin bolt with bushings and nuts, clamping.
  • Correct install locations on all the findings of the stator windings, tighten the nuts to connect them.
  • Reinstall the bolts, which made mounting the rectifier Assembly. Tighten.
  • Put the relay-regulator and tighten bolts of its fastening.
  • Install the plastic cover and lock the latches.
  • Install the alternator on the car, pull the belt and check the operation.

What to replace the generator VAZ 2114?

generator bearing VAZ 2114

VAZ 2114 – a car which very often undergoes modifications (tuning). First and foremost, of course, put a high-quality and powerful music. Some care about the comfort, make installation of xenon, Eura, air conditioning. From this the load on the generator becomes higher, “native” is not able to cope with it. Most often the replacement of staff are looking for new VAZ models – «Kalina», "prior". The replacement of the generator VAZ 2114 is quite simple. It can make any motorist, if he knows how to handle a wrench. In addition to the new generator, you'll need:

  • Wrench on the cap and “10” and “13”.
  • Carob keys for “17” and “19”.
  • Screwdriver.
  • A Small pry bar.
  • In Other words, all those tools necessary for removinginstallation.

How to replace the generator

what is the generator VAZ 2114

Regardless of which generator VAZ 2114 you put ("priors” or “Snowball”), the replacement process is the same. To replace, follow these steps:

  • Disconnect negative cable from battery.
  • Remove the engine protection.
  • With the key on “10” remove the nut from the bolt on the alternator (output, “31”).
  • Disconnect the wire going to the brushes.
  • Remove all the nuts and bolts that made the mount housing of the generator to a tension lath and block of ice.
  • Removed alternator.
  • Install new in reverse order.

Make Sure to properly stretch the strap, otherwise the bearing will quickly fail. This work is over: after a well-done repair to the generator to supply at least three years (or 50 kilometers).


Article in other languages:

AR: https://tostpost.com/ar/cars/9590-vaz-2114.html

BE: https://tostpost.com/be/a-tamab-l/17233-vaz-2114-generatar-aglyad-nyaspra-nasc-parady-pa-regulyavann.html

DE: https://tostpost.com/de/autos/17239-vaz-2114-generator-bersicht-fehler-tipps-zur-einstellung.html

ES: https://tostpost.com/es/coches/17250-los-floreros-2114-el-generador-de-la-visi-n-de-la-falla-de-los-consejo.html

HI: https://tostpost.com/hi/cars/9597-2114.html

JA: https://tostpost.com/ja/cars/9596-vaz-2114.html

KK: https://tostpost.com/kk/avtomobil-der/17230-vaz-2114-generator-sholu-a-aular-ke-ester-retteu.html

PL: https://tostpost.com/pl/samochody/17208-vaz-2114-generator-przegl-d-usterki-porady-w-przepisie.html

PT: https://tostpost.com/pt/carros/17207-vaz-2114-gerador-vis-o-geral-o-mau-funcionamento-o-conselho-de-regula-.html

TR: https://tostpost.com/tr/arabalar/17239-vaz-2114-jenerat-r-genel-bir-bak-ar-za-ipu-lar-ayarlama.html

UK: https://tostpost.com/uk/avtomob-l/17222-vaz-2114-generator-oglyad-nespravnost-poradi-po-regulyuvannyu.html

ZH: https://tostpost.com/zh/cars/10452-vaz2114.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

The truck

The truck "Mercedes 609": description, technical specifications and reviews

"Mercedes 609" – is a universal vehicle for transporting various loads. This model belongs to the second generation of the T2 family of the German company Mercedes-Benz, which was made in the period from 1986 to 1996.Distinc...

Alarm system Starline A91: AutoPlay how to enable? Car alarm: user manual, reviews

Alarm system Starline A91: AutoPlay how to enable? Car alarm: user manual, reviews

Every vehicle owner has taken all necessary measures to protect your car from theft, burglary or other unexpected troubles. Domestic drivers of different brands of machines have long been known alarm system Starline A91. How to en...

The Octavia Scout is a sensible car group Skoda

The Octavia Scout is a sensible car group Skoda

“Octavia Scout – present reasonable car group Skoda. This definition deserve only the best model, - the member of the Board of Directors of the company Frank Welsh, responsible for the technical development. – Ou...

Popping sound from faulty CV joint: how to define failure?

Popping sound from faulty CV joint: how to define failure?

Vehicles with front-wheel drive are very popular with motorists around the world. Often the design of such machines use a suspension system of a type “McPherson”. This is a very simple and reliable design that can work...

SUV UAZ hunter

SUV UAZ hunter

UAZ hunter came to replace the UAZ-3151 (or 469), produced more than thirty years. Externally, the new SUV is reminiscent of its legendary predecessor, but it is created on a completely new platform. The use of modern components a...

Full review of the Skoda car A5. Octavia II - leader of sales in Russia

Full review of the Skoda car A5. Octavia II - leader of sales in Russia

for a long time the majority of Russian motorists loved the car, belonging to the Golf class. No exception was the car of the Czech origin "Skoda Octavia" A5. The story of this model began in 1996 In twenty years, the demand has n...