How to check the clutch yourself?

Date:

2018-06-01 22:00:29

Views:

978

Rating:

1Like 0Dislike

Share:

Table of contents:

Noise and extraneous knocks – standard signs of clutch problems that may occur in a variety of situations. Also this is an incomplete turn on or off, stuck pedal, spinning the wheels. If any of the listed problems are, then you need to check the clutch. How to do it? This is what we will discuss in this article.

how to check the clutch

How to check the clutch?

There are several test procedures. The main is based on the use of measuring equipment, which you do, probably not. We are talking about special measuring gauge. The advantage of this method lies in the fact that the clutch plates do not require disassembly – enough to raise the car on the lift.

This check will take a long time, but the method will provide accurate result. This method uses a HUNDRED. How to check the clutch on the car? There are other alternative methods that do not require equipment.

Check if slippage

how to check the grip VAZ

This verification is done in case if there are prerequisites to improper clutch operation. But depending on the nature of the damage the technique can vary. The most common situation – it is a slipping clutch. In this case, the correct operation is verified as follows:

  1. Put the car on the handbrake.
  2. Startup engine.
  3. Activate third gear (fourth).
  4. Squeeze the grip and squeezing the gas pedal.

If the motor has stalled, then most likely the clutch disc is worn and requires replacement. However, this result is not always accurate.

Recommended

"IZH 350 Planeta Sport" – frisky Soviet bike

It is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the line went down the fir...

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

Check slip

How to check the clutch disc yet? The second method does not involve using any special techniques. The driver when driving in city mode just need to monitor closely the behavior of the car. For example, if the machine is very hard going up, there is a burning smell or a drop in speed for no apparent reason, there is a slip. In this case, you can try to replace the clutch disc, but in this case the perpetrators of such behavior can be transportation and other elements of the system and the clutch may be defective. So will require additional diagnosis.

how to check the clutch on the car

When the clutch "leads"

When the clutch "leads", that there are unpleasant sounds from the gearbox, and transmission to include becomes more difficult. In this case, there is a way to test the clutch:

  1. Turn on the motor, put the transmission into neutral.
  2. Squeeze the clutch pedal.
  3. To be Included first.

If the activation transmission has to make an effort and so there are strange sounds from the box, it first says that the disk flywheel not disengaging. More often than not this problem is solved by means of pumping hydraulics and adjust the pedal.

how to check the clutch

Check disc wear

Recall that the clutch disk definitely has its share. Many car owners forget about it and only change when drive a car becomes uncomfortable. In the urban driving mode, this resource decreases rapidly, and if the machine "ran" around 70-80 thousand kilometers in the city, then the clutch disc is simply obliged to "act up". However, when traffic on roads the car can travel more than 300 thousand miles without replacing the clutch.

The easiest way to determine the degree of wear of the clutch disc through the pedal stroke. To do this:

  1. Install the machine on a level surface.
  2. Start the engine and warm up to operating temperature.
  3. Engage first gear and slowly release the clutch. This is not to allow the engine stalled. Please note, at what point starts the transmission of torque to the wheels. When the vibration in the machine will stop the test.

If the clutch start to grab at the beginning of the pedal stroke, it says that with a disk everything is in order and its degree of wear or low, or no (the disk is new). If the setting is in the middle of the pedal stroke, it may indicate deterioration of the disc, but not always. On some machines like pedal adjustment, where the disc catches on the middle of the pedal stroke.

In that case, if the setting is at the very end of pedal travel or even a slip, it is indicative of worn-out disk that requires replacement. In the presence of the smell of burning clutch disc needs to be changed urgently, otherwise there is a risk of damage to the flywheel.

how to check cylinder clutch

Check the release bearing

It is not Enough just to know how to check the clutch. You should also be able to check the release bearing because this element in the transmission system plays an important role. Often damage to confuse with damage to the entire clutch system.

Validation is performed when you pressed the clutch pedal, since in this position transfers the torque to the bearing. He walks away and pulls the clutch disc. Therefore it is not recommended to hold down the clutch pedalfor too long, because it has an unstable load on a given part and leads to its rapid wear.

A Clear sign of wear of a bearing – sounds while pressing the clutch pedal (knocks, noises). However, if such sounds appear in cold weather, do not worry. This detail at low temperatures has a low coefficient of expansion due to the high strength of the steel. And the glass, where the whole site has a high coefficient of expansion. Therefore, when heated, the sound should be lost.

In addition, there are other signs that indicate faulty clutch: improper shifting, failure to include some transmission at all. Also pay attention to the twitching of the car when driving at speeds.

How to check the clutch cylinders?

In case of faulty cylinders, the vehicle may either not respond to pressing the clutch pedal at all, or respond incorrectly. Motorists often, which is a main or auxiliary cylinder, complaining that the car starts moving even if I press the clutch pedal. It primarily tells about the faulty cylinder. To check them simply considering that to break there is especially nothing, it is only necessary to check if there are any drips fluid in the cabin (just above the clutch pedal and under the hood). If no drips, then most likely, with the cylinders all right.

Conclusion

Now you know how to check the clutch. Of course, the high accuracy of verification can not be guaranteed, so in any case when you suspect a problem it is advisable to contact a HUNDRED. There know how to check the clutch vases and other brands of automobiles, including rare cars. On some foreign cars of the methods described above do not work.


Article in other languages:

AR: https://tostpost.com/ar/cars/5824-how-to-check-the-clutch-yourself.html

BE: https://tostpost.com/be/a-tamab-l/10360-yak-praveryc-schaplenne-samomu.html

DE: https://tostpost.com/de/autos/10360-wie-berpr-fen-sie-die-kupplung-selbst.html

ES: https://tostpost.com/es/coches/10365-c-mo-comprobar-el-embrague-por-uno-mismo.html

HI: https://tostpost.com/hi/cars/5827-how-to-check-the-clutch-yourself.html

JA: https://tostpost.com/ja/cars/5825-how-to-check-the-clutch-yourself.html

KK: https://tostpost.com/kk/avtomobil-der/10362-tekseru-l-n-su-e.html

PL: https://tostpost.com/pl/samochody/10361-jak-sprawdzi-sprz-g-o-samemu.html

PT: https://tostpost.com/pt/carros/10357-como-verificar-a-ader-ncia-a-si-mesmo.html

TR: https://tostpost.com/tr/arabalar/10367-nas-l-kontrol-kavrama-kendisi.html

UK: https://tostpost.com/uk/avtomob-l/10363-yak-perev-riti-zcheplennya-samomu.html

ZH: https://tostpost.com/zh/cars/6332-how-to-check-the-clutch-yourself.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

Snowmobiles

Snowmobiles "Russian mechanics": comparison and prices

the snowmobiles today are a sought-after commodity. Buy them both for fun and as an assistant on the farm. Their presence is vital to where along with the winter comes a complete transport blockade, to save from which can only sno...

"Tonar" - what's that? Models and their characteristics

“Tonar” is a well - known manufacturer. For twenty years he managed to win a place on the Russian and foreign markets. The significant amount of production involved in manufacturing of dump trucks.technologythe Truck &...

The starter is spinning but not spinning the engine. Why is the starter scrolls

The starter is spinning but not spinning the engine. Why is the starter scrolls

What to do if the starter is spinning but not spinning the engine, not it cranks the crankshaft? The reasons for this behavior, they should further study and consider methods of eliminating. It is possible that you will immediatel...

Scooter Honda Dio AF 18: specifications, tuning

Scooter Honda Dio AF 18: specifications, tuning

the First model of scooter Honda Dio AF 18 from the Japanese manufacturer with a world name first appeared in the mid-nineties of the last century. Originally it was a modification, equipped with brake unit drum. Then there were t...

Motor oil

Motor oil "Kiks": description, technical specifications and reviews

Motor oil ensures the normal functioning of the mechanisms of the engine. From the correctness of his choice depends on the duration of the entire Assembly. The lubricant must have a certain set of qualities. This allows to provid...

List of Japanese brands of cars (photos)

List of Japanese brands of cars (photos)

Japan is often ahead of other countries in matters of technological progress, not least in terms of the automotive industry. Therefore, the list of Japanese brands of cars are known to many connoisseurs of quality vehicles –...