Bad heats the stove 2110: causes and their elimination. How to alter the stove VAZ 2110?

Date:

2019-11-29 21:00:24

Views:

566

Rating:

1Like 0Dislike

Share:

Table of contents:

The Problem with a poorly working heater are found not only in the domestic “classics”, but also on more modern machines. VAZ-2110 is no exception. In practice it turns out that in the summer, if you turn the stove will be very hot, and in winter, on the contrary, the sense of it is minimal. However, it is difficult to say why this happens, so you need to consider a number of actual causes and try to eliminate them. Let's look at why bad heats the stove VAZ-2110 and how to deal with it.

bad heats the stove VAZ 2110

A Little about the design

The model VAZ-2110, which is as close to the European sample, there are many flaws, especially the heater. In our case it is separate and consists of several elements. The first, in fact, the heater is under the hood. Its mission – to prepare the air that is fed into the cabin. Here refers to the speed and temperature. The second element is in the cabin, and that the air distributor. If you have a bad warm stove VAZ-2110 (16 valve), then the first thing you need to understand which of the two nodes is not working properly. It's all quite simple. Now you will understand why.

If you do not have the ability to switch fan speed, and it is in the heater, it is logical to conclude that you have a faulty. Of course, it can be in electronics, but this is a very rare case. By the way, it is important to understand the principle of operation of the stove. It is that you set the temperature with a special sensor is compared to one that is now in the cabin. If the difference is significant, more than 2-3 degrees Celsius, the gearmotor drives the valves, opening or closing them. If the difference of the temperature more than 5 degrees, then turns on the second fan speed, if less then the first. Warm or cold air flows through the channels. So he goes on the side front glass, windshield, and feet directly on the passengers. A very common cause of bad leg oven heats VAZ-21103 and blows glass fine. Here the cause could be clogged ducts. How to clean them, we will deal with later.

Recommended

"IZH 350 Planeta Sport" – frisky Soviet bike

It is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the line went down the fir...

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

how to remake the stove VAZ 2110

How to convert the stove on VAZ-2110?

If you fundamentally do not like the heater on your machine, you without problems will be able to alter by itself. If you are faced with the problem of insufficient cooling, the fogging of the Windows in rainy weather, it is necessary to take action. First, you should make sure that the heater is healthy and normal, if not, it must be repaired, and only then proceed to action. The main reason because of which side of the glass receives little air, is that most of the flow is lost in the cracks. Accordingly, you need to take the panel apart and using the foam to eliminate air leakage. Make it pretty easy. Sometimes it makes sense to lay the flute, but in practice it works not always. It is possible to heat only the legs of the front passengers.

Note that we need to Refine and blowout of the rear passengers feet. But before you alter the stove on VAZ-2110, you need to take care of the driver's seat. Here you will have to deal with the so-called “herringbone”. Just in this case it is advisable the use of corrugations. First, it will give the desired effect, and secondly, it takes much less space the same “Christmas trees”. It is desirable that the tube was not more than 40 millimeters in diameter, and at great length, smooth inside. Otherwise, during the passage through it of air it can whistle, which is not very nice.

bad heats the stove VAZ 21103

Refinement of the damper and blower

Many drivers could face such a problem that when the big frost there is no possibility to regulate a uniform flow of warm air in all directions. It turns out that the side Windows are covered with ice, the legs freeze. For example, if bad heats the stove VAZ-21103, then here it is, obviously, in the dampers. So, TC, which were released after 2003, this is not a problem, but those that went off the Assembly line before, this will have to work. There's nothing complicated, you'll need to cut a normal blade on the metal edge of the flap (the flap windscreen do not need to touch). You can still cut off a bit from the damper, the supply air on the side of the glass. As a result, if you put the choke on the feet, then approximately 50% will go on the side Windows, 25% on the feet and 25% on the windshield. If you set the position on the windshield, then will blow only his.

Another reason why bad heats the stove VAZ-21103, is that air cooling is insufficient. Let's modify it. For this you will need dust caps and grille. With the help of elastic bands fasten the grate to the trench, using any suitable adhesive. On the back side of the boot fastened with hose clamp or tie and enjoy the result. This solution is not ideal for the driver's seat, so how much will warm right foot, but for passengers the most. Well, now let's go further, because we still have many things to consider.

Possible cause

Let's take a closer look with why bad heats the stove VAZ-2110. The reason there can be a variety. Oneof the most common is that the engine cooling system no coolant, or the amount fell below the level of “low”. To find out whether this is so, it is necessary to look into the expansion tank and check the level, if necessary top up with antifreeze or antifreeze. Another quite important cause could be the heater core. He often goes down and stays cold when should be hot. It's not uncommon for “ten” in the radiator formed a gap. It is quite natural that with a crack or hole in the casing, it will not heat.

bad heats the stove VAZ 2110 the reasons

The Air tube – another reason for the failure of the radiator. In the best case it will resolve if to drive the front wheels on a small hill running at a medium speed engine and to stand so for a few minutes. Sometimes it is enough just to replace the filter in the cabin. As you can see, not so easy to understand why bad heats the stove VAZ-2110. The reasons may be different, for example, the controller SAWA or microbioreactors. If in some cases you'll need to spend only five minutes to solve the problem, others may take much more time. Let's see, what to do if the heater completely refuses to work properly.

Faulty temperature sensor

Quite often the problem follows: you can't properly adjust the compartment temperature as the sensor, which is located near the lighting bulb has failed or is not calibrated. Most often the problem lies in the failure of the control unit, as well as an incorrect position of the flap. Fortunately, all this is quite easy, only need some time and tools. The first step is to diagnose a faulty temperature sensor. This can be done in the following way: translate the handle of management of heating in one direction and then in the opposite. The temperature entering the interior air needs to change.bad heats the stove VAZ 21102

If the temperature changes, but still bad warm stove VAZ-21102, it's not in the controller. In the case where there is no change, it makes sense to replace the sensor or just try to disable it and to check the efficiency of the heater. If the controller is off, the cabin will do the air of such temperature that has been set on the electronic block. If to speak simple words, so you will be able to turn off “A” on the fan. Well, now let's go ahead and consider a few of the faults of the stove on “ten”.

Bad heats the stove VAZ-2110 idle

If you noticed that one "perfect" morning when the engine is warm and the heater is blowing cold air, you have to take action. Most likely, it is a faulty thermostat or the pump. In principle, the device of the stove is relatively simple, and the essence is to hot antifreeze got into the heater radiator. Through the radiator by the fan is blown cold air, which during this time is heated and passes into the cabin. If the salon does not hot or even warm stream, then you need in some place to look for the fault. One of the main reasons can be a broken gasket head to cylinder block. In this case, the system will be in zavotdeleniem condition. Immediately note a big circle cooling and a faulty thermostat.

But that's not the worst thing that can happen. Much sadder is the situation when bad heats the stove VAZ-2110 (8 valves) due to a failed pump. In this case, it may happen overheating of the engine as the cooling system is not circulating the antifreeze. If the stove works several times worse than before, check the pump. Faulty tap – another important reason. In this case, the input hose hot and the output – the cold. If you manually open the tap did not work, just replace it, sometimes a simple cleaning with compressed air.

If you have a broken gear or a heater

In most cases this element will not be repaired, much easier to replace it. It is very simple, and we now consider the sequence. If bad heats the stove VAZ-2110, thermostat and pump and not, and also no air tube, the air is still blowing cold or barely warm, you have to change the gear. To do this, remove the windscreen wipers and dismantle the "frill" (you need to Unscrew three screws). Then unhook all the wires that come to the gearmotor and remove it. Then just plug in new part and a friend helped carry out the adjustment of the air entering the cabin.

bad heats the stove VAZ 2110 8 valves

Sometimes it makes sense to check directly the heater. It breaks quite rare, but from it nobody is insured. To make sure its faulty or normal operation, it is necessary to remove the main baffle. Then you need to straighten fasteners. To push the flap more convenient from the side of the engine compartment. A large number of scale, in the same way as mechanical damage (crack, hole etc.), says that will need to be replaced. Remember that if bad heats the stove VAZ-2110 (injector, 8 valve) and it's in the radiator, you will need to fullyto disassemble the stove in order to replace it. This is not so easy, but with due diligence and free time it can be done.

Stove warms bad air or airflow insufficient quality

Sometimes the air is heated very slowly, which is clearly not delighted with, especially in severe frosts. In addition, it also happens that the quality of the warm stream is not very satisfying. In this case you need to replace the plastic flap on the aluminum. The latter is more expensive, but its effectiveness is significantly higher. As practice shows, many drivers are faced with the fact that the flap of the old sample is curved during operation, which leads to loss of heated air. If you are willing to pay for heat in the cabin, get a heater from the VAZ-2112. It is somewhat better, although it may not have the cleaning filter or none the function of recycling (depending on model).

You Can also buy a antifreeze heater. He needed to preheat the engine and passenger compartment. If you are not satisfied with how well air is supplied on the side glass and under the feet, then you may improve the system independently. How to do it, we're told. Pay attention that the nozzle can be closed or something or crammed. So, often the drivers close their mats, without knowing it. But all this is quite simply eliminated, just need to take the time. As you can see, if bad heats the stove VAZ-2110 (injector), then the reasons can be a whole lot. Most often you can correct yourself.

About the problems with damper

As mentioned a little above, on the factory install two types of valves: old and new model. In the first case, it is plastic with gasket foam. A special quality she does not possess and in the process of operation of tubes. The second type is more reliable, as the valve metal, and the rubber gasket. So, VAZ-2110 has two flaps: upper and lower. The first is responsible for the flow of cold air into the cabin, the second - for the arrival warm. If when you switch the knob you hear the door move, but the air is cold, blowing and blowing, it is quite possible that down came the actuator or valve. In the latter case, it is easier to change to a new one. In some cases it makes sense to use glue, for example dichloroethane. However, you need to understand that you have to disassemble the heater, and it is time consuming.

bad heats the stove VAZ 2110 thermostat

By the controller of SAWA push the lever to the minimum. Needs to blow cold air. If you have transferred to the maximum, and there will be no flow, this indicates a malfunction of the lower flap, which is responsible for supplying warm air. But you need to follow, whether the top is closed. If cold flow is not, then it is closed. Another likely cause – jamming. This happens due to simple misalignment or jamming due to rust. Can try to remove the Central air vent, climb up the flapper with your hand and try to move it there. Yet this element may not fully open or close. In this case, it is easiest to replace the valve with new, higher quality.

Conclusion

As you can see, if bad heats the stove VAZ-2110 (carburetor or injector), then you first need to understand what the cause of the fault. The solution to this problem may take only a few minutes (for example, disable temperature sensor) and all day (removing the lining and repair of minimotorbike or its replacement). You have great confidence to say that any malfunction sooner or later appear. The point here is, rather, not of negligence of the driver, and the build quality. However Volzhsky automobile plant produces very tolerable vehicles. Well, in principle, all that can be said about what are the problems with the stove and how to deal with such faults. Each case of heater failure is different, so you may not find solutions in this article. Nevertheless, there are described the problems encountered most often. You can save hundreds or even thousands of rubles for the repair and to do everything with your hands. In return, you get valuable experience which you can use in the future to Refine or repair the stove of your car.


Article in other languages:

AR: https://tostpost.com/ar/cars/20078-2110-vaz-2110.html

BE: https://tostpost.com/be/a-tamab-l/37763-drenna-gree-pechka-vaz-2110-prychyny-h-l-kv-dacyyu-yak-perarab-c-pechk.html

DE: https://tostpost.com/de/autos/37394-schlecht-heizt-der-ofen-vaz-2110-ursachen-und-deren-beseitigung-wie-ma.html

ES: https://tostpost.com/es/coches/37162-mal-calienta-la-estufa-de-los-floreros-2110-causas-y-soluciones-como-m.html

HI: https://tostpost.com/hi/cars/21771-2110-2110.html

JA: https://tostpost.com/ja/cars/19714-2110-vaz2110.html

KK: https://tostpost.com/kk/avtomobil-der/38136-zhaman-zhylytyp-t-r-anda-pechka-vaz-2110-sebepter-zh-ne-olardy-zhoyu-r.html

PL: https://tostpost.com/pl/samochody/38389-s-abo-grzeje-piec-vaz-2110-przyczyny-i-ich-usuwanie-jak-przerobi-piec-.html

PT: https://tostpost.com/pt/carros/38563-mal-aquece-fog-o-vaz-2110-causas-e-corre-es-como-refazer-o-fog-o-vaz-2.html

TR: https://tostpost.com/tr/arabalar/34624-k-t-s-cak-soba-vaz-2110-nedenleri-ve-bunlar-n-giderilmesi-olarak-yenid.html

UK: https://tostpost.com/uk/avtomob-l/38536-pogano-gr-p-chka-vaz-2110-prichini-h-usunennya-yak-pererobiti-p-ch-vaz.html

ZH: https://tostpost.com/zh/cars/18742-2110-2110.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

Gel battery reviews:. Gel battery: the device and features

Gel battery reviews:. Gel battery: the device and features

Almost every one of us have heard that there are gel batteries. All say that they are very effective and have a number of advantages. Despite the fact that this battery has more than 30 years, the greatest popularity they have gai...

Snowmobile

Snowmobile "Dingo 150": reviews and specifications

the Modern snowmobile is a specialized vehicle designed to move on snow. They are used in various spheres of human activity and is needed to allow safe and rapid movement through various snowy areas.snowmobiles are manufactured fr...

MAZ-200: specifications, price, reviews, and photos

MAZ-200: specifications, price, reviews, and photos

Soviet truck MAZ-200 (photo on the page) is the most powerful car created in the postwar period. In 1945 the last century at the Yaroslavl automobile plant was assembled prototypes of the legendary machine. There have been tested....

On a cold but the fact: the main causes

On a cold but the fact: the main causes

the internal combustion Engine is used on automobiles for over a century. And its design is constantly being improved. However, despite global modernisation, the majority of failures of internal combustion engines are already know...

"AQUASTOP": reviews. Protection of the car body AquaStop

Every time after heavy rain motorists have to think about how you can quickly and efficiently wash your car. Of course, I want to get the look of the car is not spoiled never, however, miracles, unfortunately, does not happen. But...

All-terrain vehicle

All-terrain vehicle "Petrovich": specifications and reviews

off-road transport, despite the competition with the SUV, and always will be very popular in Russia. And if earlier to us imported jeeps only of foreign origin, that its cost was comparable to a luxury item, but now, thanks to the...