Replacing the pump VAZ-2109: price, reviews. Replacing the pump VAZ-2109 with his own hands

Date:

2019-12-03 23:20:11

Views:

477

Rating:

1Like 0Dislike

Share:

Table of contents:

Replacing the pump VAZ 2109 every 90 thousand kilometers. It is a guaranteed resource it provided that it is operated in a normal mode, and the cooling system refilled with antifreeze. The fact that antifreeze contains additives, it is thick and dense, therefore, it is bearing lubrication pump. But everything in order, we must first determine how often you need to replace. Because you know, what will it take to drain all the liquid from the system. And this is not a pleasant occupation.

Question: when to change the pump?

replacing the pump VAZ 2109

Of Course, the conversation is not going on the emergency replacement. The cases are different, could the pump housing to crack or the seal from the factory or got married too pulled the timing belt, why the bearing broke. Now it would be a normal, standard situation. Timely service, quality parts, maintenance is not hard. In this case, replace the water pump 2109 should be conducted every 90 thousand mileage.

Now, notice that the timing belt be replaced every 60 thousand. But this is assuming that the car has age less than seven years. Unfortunately, these young Niners no, they were discontinued. It is therefore recommended to reduce the mileage to 45-50 thousand. Therefore, the pump should be changed through the single strap.

Replacement antifreeze

replacing the pump VAZ 2109 injector

Now about the antifreeze should say a few words. Its additives evaporate or become useless in about two years of operation of the car in mid mode. And in a year the average car drives about 35-40 thousand. Assuming daily use of transport. This means that when 80 thousands need to replace the antifreeze. Often you observe this pattern? Therefore, with each replacement pump, it is recommended to fill with fresh antifreeze. And at best – flushing of the entire system and purge with compressed air. For flushing you need to use clean water and a special liquid. It can be purchased at any auto parts store.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

Possible damage to the pump

replace water pump VAZ 2109

So what can happen with such a fluid pump, for whatever reason, you need to replace the pump VAZ 2109? If you look at the feedback from the drivers, it appears that the cracks appear on the body, but not very often. It's such a failure that happens only with the original factory second. Not to get on it, carefully inspect the pump before purchase. The fact that many stores don't take back the item, even if you were not trying to be.

Often occurs the destruction of the bearing of the pump. Smeared it with antifreeze, so if the operation of the vehicle filled the system with water starts the strongest wear of the balls and clips. Also the bearing is destroyed in the case of strong tension of the timing belt. Because it is pump driven. Often wears out the oil seal, which prevents the release of antifreeze from the system on a rotor of the pump. Rarely is the destruction of the impeller. This mechanism, which is so damaging.

What to expect from damage the pump?

replacing the pump VAZ 2109 price

What can happen if there is a malfunction of the liquid pump? First, when almost any damage to the pump will leak fluid. It will begin slowly at first dribble, but as they wear, the pressure will increase. But do not be sad about it, replacing the pump VAZ 2109, which price is 700-900 rubles, will remedy the situation. The kit also includes a gasket and three bolt mounting.

But the destruction of the bearing, for example, the leak may not appear, but you can observe another phenomenon, which will put you in a deadlock. The timing belt will start to wear off from the outside. And will remain a thin edge. This happens for the reason that the pulley the pump starts to shift to the side, it slides the belt. the latter begins to RUB on the idler pulley, which it gradually destroys.

How to remove the pump

Before beginning work, be sure to let the engine cool down. First, it is easier to drain the fluid from the system. Secondly, it is more convenient to work in the engine. Of course, if the repair is done in bitter cold, not to cool the motor. Then poured the liquid into the container. Two holes for draining – on the engine block and at the bottom of the radiator. It is possible that some of the antifreeze to be spilled, so you should be a small amount of filling. Try to pre-stock all the necessary material to go faster replacing the pump VAZ 2109. Injector or a carburetor based on the injection system no matter pump liquid in both cases is the same.

Now you need to Unscrew the three bolts that held the fastener of plastic cover. And opens a lovely view of the timing drive. No mercy twisting the tension pulley and remove the belt. That's all, now you can start the pump. It is secured by three bolts with a cap on 10. If necessary, first clean the surface. Remove the bolts, just remove the pump housing will not work. You need a flat screwdriver to press it from the engine block. he's pretty firmly seated in the groove.

Installing a new pump

replacementt of the pump VAZ 2109

Before installation, thoroughly clean the surface on the block, which is in contact with the pump. Get rid of the remnants of the old gasket. Now, to make repairs of the highest quality, take a sealant and apply a thin layer of it on the gasket surface. Immediately don't wait 1-2 minutes. After that, install the gasket to the pump, aligning the holes. That's it, now assemble the pump body, if necessary, tap with a hammer through the wooden prorate.

Ready, you can now loosely install the bolts and hand tighten them. The tightness is better to spend 15 to 20 minutes, to allow the sealer started to set. That's the whole renovation, it remains only to check the status of all connection pipes of the system, if necessary, replace them. And you can safely pour the liquid into the expansion tank. It is also worth noting that the replacement of gland packing pumps 2109 may not produce the desired result. Yes, the leak is resolved, but in a short time can break the bearing. Not to do double work, easier to just put in a new pump.


Article in other languages:

AR: https://tostpost.com/ar/cars/19771-vaz-2109-vaz-2109.html

BE: https://tostpost.com/be/a-tamab-l/32392-zamena-pompy-vaz-2109-cana-vodguk-zamena-pompy-vaz-2109-sva-m-rukam.html

DE: https://tostpost.com/de/autos/33000-ersatz-pumpe-vaz-2109-preis-bewertungen-ersatz-pumpe-vaz-2109-mit-den-.html

ES: https://tostpost.com/es/coches/33228-sustituci-n-de-la-bomba-de-vaz-2109-el-precio-los-clientes-sustituci-n.html

HI: https://tostpost.com/hi/cars/17999-2109--2109.html

JA: https://tostpost.com/ja/cars/19772-vaz-2109-vaz-2109.html

KK: https://tostpost.com/kk/avtomobil-der/32065-pompany-auystyru-vaz-2109-ba-a-syn-p-k-rler-pompany-auystyru-vaz-2109-.html

PL: https://tostpost.com/pl/samochody/31384-wymiana-pompy-vaz-2109-cena-opinie-wymiana-pompy-vaz-2109-w-asnymi-r-k.html

PT: https://tostpost.com/pt/carros/31411-substitui-o-da-bomba-de-prot-es-vaz-2109-pre-o-para-o-viajante-substit.html

TR: https://tostpost.com/tr/arabalar/34669-yedek-pompa-vaz-2109-fiyat-de-erlendirme-yedek-pompa-vaz-2109-kendi-el.html

UK: https://tostpost.com/uk/avtomob-l/31470-zam-na-pompi-vaz-2109-c-na-v-dguki-zam-na-pompi-vaz-2109-svo-mi-rukami.html

ZH: https://tostpost.com/zh/cars/17114-vaz-2109-vaz-2109.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

SUV

SUV "SsangYong Rexton"

Frame-based SUVs have a high security due to the more rigid body. Ssangyong Rexton - first-frame SUV in the model range of the Korean company "SsangYong". Model quite quickly gained its market share due to low prices compared to c...

Brake system VAZ-2107: diagram, device, repair

Brake system VAZ-2107: diagram, device, repair

Very important is the role of the braking system of VAZ-2107 car. With its help, the stop of the machine. The effectiveness of inhibition depends on everything. Timely stop the vehicle necessary to prevent collision or hitting an ...

Electronic ignition on VAZ 2107: installation and scheme

Electronic ignition on VAZ 2107: installation and scheme

Use electronic ignition on VAZ 2107 is much more efficient than contact. To understand what benefits are available when you install contactless system, it is necessary to consider briefly the history of its development. And start,...

Oil

Oil "Castrol Magnatek 5W40": reviews. Motor oil Castrol Magnatec 5W-40

many service stations offer motorists oil and other liquids this manufacturer. But what do we know about this product? What are the characteristics of the oil "Castrol"? They are better than most popular brands like Motul? What te...

Even nezabytyy motorcycle

Even nezabytyy motorcycle "Dnepr"

Legends are not born, legends are. The same can be said about motorcycle «Dnepr». More recently, the product of the Kyiv motorcycle factory, all across the country, proudly announcing the street with a growl of its mot...