Lost spark on a scooter: possible causes and their elimination. Repair scooter own hands

Date:

2020-01-08 03:00:16

Views:

498

Rating:

1Like 0Dislike

Share:

Table of contents:

Scooters are relevant, popular and practical vehicles. They can successfully move people of different ages. For most owners, the scooter – and is the only means of transportation. Other owners have used this technique as entertainment. In the process of exploitation of Chinese and Japanese scooter, you may experience various malfunctions. One of the common problems faced by many – lost spark on a scooter. Consider the possible reasons and solutions for this trouble. lost spark on a scooterOften the spark is lost at the most inopportune time, and the driver was saddened by the stalled motor. Especially often the problem faced by owners of Chinese art.

General Troubleshooting

If the engine of a moped stalled, you first need to figure out why it happened. Indeed, among the main reasons why the engine stalls on the road or refuses to start, only two – lack of fuel or the inability to ignite the mixture. Often with first diagnosis, it appears that the gasoline in the tank is, and the fuel mixture is fed into the cylinders through the vacuum. And so the culprit is the fact that missing spark on a scooter. To verify this, simply remove the candle from its standard holes in the cylinder. She then inserted in the cap end is attached to the housing of the motor.

Then the engine plant and look at the electrodes. You should also check the element not only on the presence of spark, but on the condition of the electrodes. The candle can be dry or wet. If the electrode is wet, then the culprit is not the power supply system, and carburetor and no spark. If missing spark on a scooter 4T, the reasons may be different. Most likely we will see below.

Recommended

How does the rear bushing front arm and how many it serves?

How does the rear bushing front arm and how many it serves?

The Rear bushing front arm – one of the constituent elements of the vehicle chassis. He refers to the guide elements of the suspension together with the levers endures tremendous stress with wheels. However, with this this item, there are many ...

Oil consumption in the engine. Six reasons

Oil consumption in the engine. Six reasons

It is Hardly possible to find a motorist who would not be worried about the increased oil consumption. It is especially annoying when it happens with another new motor. Here are the most common causes that result in the consumption of oil in the engi...

How does the exhaust system?

How does the exhaust system?

The exhaust System is designed to remove combustion products from the engine and output them to the environment. It also must be ensured a reduction in noise pollution to acceptable limits. Like any other complex devices, this system consists of seve...

Faulty spark

This is the simple reason why at the electrodes is no spark. This problem often happens due to fuel quality, and also due to the presence in the composition of domestic gasoline different harmful impurities. Because of this, many owners of Chinese art lost spark on a scooter 4T (4 stroke). How to check its presence?

To make sure that candle is out of order, you need to install a new one instead or just in good detail. But there are times when new is missing, and you can buy it anywhere. Then help a nail or piece of wire. You need to find such devices, the diameter of which is sufficient to wire or nail did not fall out of the cap. The element must be inserted in the candle cap, and then bring it to the motor housing. The approximate distance from nail to the Carter shall be 7 millimeters.

Next, the starter scroll the crankshaft. If the wiring of the scooter is fully functional, between the nail and the metal casing of the motor there is white spark. So the ignition system is operating normally, and it is necessary to replace a candle. You can try to clean it from soot. Thus, it will work again. But most beginners do it wrong. After such cleansing and if the spark returns, then for a very short period of time.

Clean the elements correctly

How to clean candle soot from correctly, everyone should know the owner of Moto - vehicles. Most beginners try to recover the parts yourself and then wonder why they don't work. lost spark on a scooter 4TThe Main mistake that the spark runs to the housing of the plug through the soot – it is not a conductor of electricity. The motor cannot run. Plaque is formed not only on the electrodes but also on a ceramic insulator. Therefore, it is necessary to clean not only the side and Central electrodes, and insulator.

Better effect can be achieved if you use the sandblaster. If there is none, you can try cleaning just sand. This should get the electric drill and sand in the bucket. Next, take the candle and the threads on the upper part is clamped in the Chuck of a drill. Large thread zamatyvaetsya tape. Then the item is lowered into a bucket and run the tool. After some time, the electrodes and insulator clean. If for this reason the spark was gone, the spark plug for a scooter again to work properly.

Validation in appearance

Defective item must be clean. Allowed only a slight residue on it. However, if the electrodes are melted or black, then the spark is do not be. Candles are spoiled from too rich fuel mixture. If the insulator is white, but it has small black inclusions and traces of erosion on the electrode, it says about overheating. Also evidenced by the melted electrodes, the insulator in the bubbles. If the parts have oil deposits, it can be considered faulty and best to replace with the new one. A simple repair of the scooter with your hands will help you to operate this transport.

The wire

This is the second simple reason. This refers to the cord that connects the frame of the scooter and engine. This lead and its compounds – the second thing to check after candles. It is imperative to ensure that conductor is not damaged and its contacts are not oxidized.

The Cliffs at the candle cap

The reason can also be attributed to simple. If missing spark on a scooter, you shouldremove the cap and then check its resistance level. Disconnecting the cap from the wire, make measurements. Multimeter probe is inserted into the plug hole. The other is attached to the pin to which a suitable wire. If the cap is good, the multimeter will show about 5 ohms. On most modern scooters high-voltage wires, spark cap and ignition coil is made in one-piece. on the scooter was missing the spark what to doAll these details filled rubber or compound. And so you can test the cap, wire and ignition coil in the complex. One of the probe device is inserted into the plug hole on the cap. The other is connected to the ignition coil. So identify the resistance on the primary and secondary winding and the high voltage wire itself. Readings on the primary winding should be between 0.1 Ohm to 0.4 Ohm. the gap on the spark plugsThe Resistance of the secondary - from 6.35 Ohms to 9.7 Ohms on most scooters. Sometimes in disrepair high-voltage wire. To replace it required a cable with a metal core. Not suitable for this automobile element with carbon filler.

Breaks in the wiring

It happens very often, especially on scooters made in China. There may be broken wire in the ignition system. scooter repair own handsThe reason may be oxidized contacts and terminals. Repair scooter own hands produce, in this case is to check the integrity of all wires in the ignition system. Also pay attention to the terminals. If the contacts are oxidized or hold loosely, then they should be cleaned and preload. Can't hurt to check the wire that goes from the switch. You need to make sure the connection is secure and clean the terminals.

Failure of the ignition system components

This is not a common cause. But if you lost spark on a scooter and no apparent reason not, then you should test the switch, coil, generator coil. Check out all of these devices can be the same multimeter. To make sure that the coil and impulse sender is OK, you need one probe of the tester to attach to the wire from the sensor, and the second to the crankcase.

Normal working of pulse sensor has a resistance of about 500 Ohms. The resistance of the winding of the generator two to three times less. If the multimeter reads infinity, then one of the components has failed. It should be replaced. If the value is less than 150-200 Ohms, then the problem is in the feed coil, and therefore, the scooter was missing the spark. What to do in this situation? To buy a new generator. Such a device can be repaired, but in the absence of time better just to replace it. The benefit cost of the small generator.

Switch

The location to find even for a novice. It is a plastic box with a terminal block. It colored wire. The switch needed to control the operation of the ignition system. Both the switch and ignition coil made by folding. If the element has failed, then the problem can be solved only by replacement. Price these items low - to 500 rubles. Some service stations there are special devices that allow you to test the switch. However, for a long time to search for appropriate services, it is easier to just buy a new switch. In the process of finding the causes of failure of the switch does not need to listen to “experts” who claim that the failure happened because of driving without a battery. It is an invalid opinion. The fact that modern scooters power system and the ignition system does not depend from each other.

Check circuit to ignition switch

For this purpose, the probe of the tester is attached to the wire coming from the switch pads on the ignition. lost spark on a scooter 4T the reasonsThe key in the lock turn in position “disabled”. The tester needs this position to show 0 and in the on state of the castle – infinity.

Plug Gap

The Gap on the spark plug – this is an important factor for correct engine operation. This parameter plays an important role in the process of formation of the spark, ignition of the fuel mixture, the effective operation of the scooter throughout the Rev range. The clearance should be specified in the documentation for the specific scooter – the producers of this parameter can vary. Generally speaking, for most modern four-stroke Chinese and Japanese mopeds gap on the spark plugs is 0.5 to 0.8 mm. You must monitor this parameter. For such a reason and can lose the spark. She's leaving due to too much clearance.

Fuse box

Many models of scooters equipped with protection systems against short circuits. If there is no spark, you need to find the panel with the fuses and check all the items in it. Fuses often burn and need to replace them. Then the technique will be back in the ranks.

How not to break the ignition

Ever on the scooter will have something cooking. spark plug for scooterBut before you weld, you should disconnect the switch and a voltage regulator. Otherwise, these elements will burn up.


Article in other languages:

AR: https://tostpost.com/ar/cars/20574-lost-spark-on-a-scooter-possible-causes-and-their-elimination-repair-s.html

BE: https://tostpost.com/be/a-tamab-l/38216-zn-kla-skra-na-skutary-magchymyya-prychyny-h-l-kv-dacyyu-ramont-skuter.html

DE: https://tostpost.com/de/autos/37811-verschwunden-ist-der-funke-auf-dem-roller-m-gliche-ursachen-und-deren-.html

ES: https://tostpost.com/es/coches/37607-se-ha-perdido-la-chispa-en-moto-acu-tica-para-descubrir-posibles-causa.html

HI: https://tostpost.com/hi/cars/22246-lost-spark-on-a-scooter-possible-causes-and-their-elimination-repair-s.html

JA: https://tostpost.com/ja/cars/20219-lost-spark-on-a-scooter-possible-causes-and-their-elimination-repair-s.html

KK: https://tostpost.com/kk/avtomobil-der/38624-propala-iskra-na-skutere-y-timal-sebepter-men-olardy-zhoyu-zh-ndeu-sku.html

PL: https://tostpost.com/pl/samochody/40183-znikn-a-iskra-na-skuterze-mo-liwe-przyczyny-i-ich-usuwanie-naprawa-sku.html

PT: https://tostpost.com/pt/carros/39824-o-que-desapareceu-foi-a-fa-sca-de-scooter-poss-veis-causas-e-corre-es-.html

TR: https://tostpost.com/tr/arabalar/35076-kay-p-k-v-lc-m-scooter-olas-nedenleri-ve-bunlar-n-giderilmesi-tamir-sc.html

UK: https://tostpost.com/uk/avtomob-l/39017-propala-skra-na-skuter-mozhliv-prichini-h-usunennya-remont-skutera-svo.html

ZH: https://tostpost.com/zh/cars/32973-lost-spark-on-a-scooter-possible-causes-and-their-elimination-repair-s.html






Alin Trodden - author of the article, editor
"Hi, I'm Alin Trodden. I write texts, read books, and look for impressions. And I'm not bad at telling you about it. I am always happy to participate in interesting projects."

Comments (0)

This article has no comment, be the first!

Add comment

Related News

"IZH 350 Planeta Sport" – frisky Soviet bike

it is believed that of the entire line of Soviet motorcycles "IZH" truly sporty just one. It is easy to guess that it was "IZH 350 Planeta Sport".History motorcycleIn 1973 the factory "Izhmash" was made a real breakthrough: the li...

Mobile feed mill installation: features and benefits

Mobile feed mill installation: features and benefits

Mobile feed mill installation is a mini-plant for production of feed for pigs and cattle out of the grain, adding various processing compositions.Descriptionthe Unit consists of the mixing device, crusher with fans for the grindin...

The theory of driving a car with manual transmission, the order of switching speeds

The theory of driving a car with manual transmission, the order of switching speeds

after Graduating from training in a driving school in America exam on the machine with mechanical and automatic transmission is for rent separately. That is, you are able to obtain the right to drive cars with automatic transmissi...

Viscous coupling: principle of operation and device

Viscous coupling: principle of operation and device

Now more popular in the automobile market got the crossovers. They have both full and monodrive. It is connected with a device such as viscous coupling. The principle of operation of the unit – further in our article.Charact...

Revision

Revision "Chevrolet Niva". Where to start?

a Very long time, domestic cars were considered if not the worst, it lags far behind on technology. After the premiere of "Niva Chevrolet" it has become clear that the domestic SUV can be much better, especially if you apply some ...

What is a timing chain? Which is better: timing chain or belt?

What is a timing chain? Which is better: timing chain or belt?

Now a lot of debate about which drive is better, naturally – a belt or timing chain. VAZ previously equipped with the latest type of drive. However, with the release of new models the manufacturer has switched to the belt. N...